Circulating Fluidized Bed(CFB) Hot Water Boiler Operation Manual

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



The primary combustion chamber is a riser like as that in vertical CFB, and the The basic principle for horizontal CFB and experiences for designing and operating are presented in this paper. horizontal circulating fluidized bed boiler (HCFB) hot water boiler steam boiler Circofluid Technology Transfer Manual, 1991.

Fluidized Bed Combustion Boiler Technology For &8211; UNEP

Technical Study Report: Biomass Fired FBC Boiler for Cogeneration. UNEP-DTIE Energy Co-generation through fluidized bed combustion (FBC) boiler.

culation-Circulating Fluidized-Bed (IR-CFB) boiler operat- ing experience, new cial operation, the latest IR-CFB design is being expanded to higher capacity to the boiler water-cooled tube enclosure and other heating surfaces (see Figure 1). .. furnace was to cool solids collected by the hot cyclone using a BFB heat

Circulating Fluidized-bed Combustion Technology (CFBC). Technology Overview. 1. Features. The features of circulating fluidized-bed boilers are described.

Within a fluidised bed furnace, biomass fuel is burned in a self-mixing suspension of gas This separately controllable primary air supply also allows smooth operation of grate .. The horizontal version is suitable for generating hot water or steam in boilers . and circulating &64258;uidised beds (CFB) have to be distinguished.

Industrial boiler systems are used for heating with hot water or steam in industrial process This fluidization improves mixing of fuel and air, as well individual bed particles, and (2) circulating bed &8211; operating at fluidizing velocity that exceed the .. For most ICI boilers, periodic testing and manual tuning are adequate.

View &8211; Department of Environmental Quality

HBPW is proposing to install an 865 MMBtu/hr circulating &64258;uidized bed boiler rated The new CFB plant cycle consists of a turbine generator with four (4) During the winter months, warm water from the steam condenser will be used to heat the hot . capital and operating costs, reliability, availability, fuel price, fhel price

Jun 22, 2012 17 2.3 Hot Start . 20 3.1 Check Up During the Boiler Operation. . 37 6.2 The curing method through water release and drying under hot state. . experiences in designing and manufacturing of the Circulating Fluidized Bed Boiler. . 1.2 Boiler Chemical Cleaning For the chemical cleaning, the CFB boiler

Projects at the power plant include water supply, waste water, auxiliary system included MPU&39;s first circulating fluidized bed (CFB) boiler which was the first CFB to be chilled water production & distribution, domestic hot water, electric T&D, Also, a due diligence analysis of adding a circulating fluidized bed

The primary combustion chamber is a riser like as that in vertical CFB, and the The basic principle for horizontal CFB and experiences for designing and operating are presented in this paper. horizontal circulating fluidized bed boiler (HCFB) hot water boiler steam boiler Circofluid Technology Transfer Manual, 1991.

Technical Study Report: Biomass Fired FBC Boiler for Cogeneration. UNEP-DTIE Energy Co-generation through fluidized bed combustion (FBC) boiler.

IR-CFB Boilers: Supercritical Once- through &8211; Babcock & Wilcox

culation-Circulating Fluidized-Bed (IR-CFB) boiler operat- ing experience, new cial operation, the latest IR-CFB design is being expanded to higher capacity to the boiler water-cooled tube enclosure and other heating surfaces (see Figure 1). .. furnace was to cool solids collected by the hot cyclone using a BFB heat

Circulating Fluidized-bed Combustion Technology (CFBC). Technology Overview. 1. Features. The features of circulating fluidized-bed boilers are described.

Within a fluidised bed furnace, biomass fuel is burned in a self-mixing suspension of gas This separately controllable primary air supply also allows smooth operation of grate .. The horizontal version is suitable for generating hot water or steam in boilers . and circulating &64258;uidised beds (CFB) have to be distinguished.

Industrial boiler systems are used for heating with hot water or steam in industrial process This fluidization improves mixing of fuel and air, as well individual bed particles, and (2) circulating bed &8211; operating at fluidizing velocity that exceed the .. For most ICI boilers, periodic testing and manual tuning are adequate.

HBPW is proposing to install an 865 MMBtu/hr circulating &64258;uidized bed boiler rated The new CFB plant cycle consists of a turbine generator with four (4) During the winter months, warm water from the steam condenser will be used to heat the hot . capital and operating costs, reliability, availability, fuel price, fhel price

BOILEROPERATION-MANUAL-330B-SM8E_(3) &8211; Scribd

Jun 22, 2012 17 2.3 Hot Start . 20 3.1 Check Up During the Boiler Operation. . 37 6.2 The curing method through water release and drying under hot state. . experiences in designing and manufacturing of the Circulating Fluidized Bed Boiler. . 1.2 Boiler Chemical Cleaning For the chemical cleaning, the CFB boiler

Projects at the power plant include water supply, waste water, auxiliary system included MPU&39;s first circulating fluidized bed (CFB) boiler which was the first CFB to be chilled water production & distribution, domestic hot water, electric T&D, Also, a due diligence analysis of adding a circulating fluidized bed