best steam boiler price

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



Find great deals on eBay for Used Steam Boiler in Heating Units. or Best Offer reduced price GENERAL BOILER steam boiler 100 PSI MODEL GE-24.

Cost of a Boiler &8211; Estimates and Prices Paid &8211; CostHelper.com

CostHelper readers report paying $3650-$7800 for a replacement boiler, including a boiler heats and distributes water, sending it through pipes as steam to because some of the best deals available are reduced prices for older folks.

Powerhouse sells used boilers and equipment from trusted manufacturers. Benefit from our vast 1-800-37-STEAM. 24/7 Emergency boiler to &8220;like new&8221; condition. Buy with confidence that you&39;re purchasing the best boiler at the best price!

Check out the cast-iron steam boiler selection at Grainger today and find Price $2,251.00 &8211; $3,749.00 .. Oil Fired Steam Boiler,22-1/8inWx35inH.

A plumber is suggesting that we replace our steam boiler rather than the price is set before knowing what kind of boiler we need (2 floors in a

I am thinking to convert oil fired boiler and electric hot water tank into gas-fired Voted Best Answer .. What is the best gas fired steam boiler?

High Efficiency Boiler Prices | U.S. Boiler Company

There is more to a high efficiency boiler upgrade than prices alone. Each year they select &8220;Best Buys&8221; in boilers based on efficiency, features, ease of condensing boilers, three-pass, oil-fired steam boilers, hot water heaters, and radiators.

Find steam boiler manufacturers and connect with various suppliers that will reliable thermal efficiencies you can count on us to provide you with the best! We are eager to provide you with exceptional steam boilers at an economical price.

TT BOILERS Electrical Heated Steam Boilers are made in an rigid industrial design for Best economy after 3 &8211; 4 years; Made in own workshop in Copenhagen, on quality are accepted and where low purchase price are not the key words.

More about pricing. Q. If I want to convert my existing boiler, what size boiler works best? Better yet, mating a Pellergy burner system to a Burnham MegaSteam boiler results in the only wood pellet fired, triple-pass, higher efficiency steam

Items 1 &8211; 36 of 60 Great Pricing on all Boilers by all your favorite brands like Weil Mclain, Weil Mclain SGO-3 85000 BTU Output Steam Oil Boiler 386-700-819.

Industrial Steam Boilers Price &8211; Alibaba

Industrial Steam Boilers Price, Buy Various High Quality Industrial Steam Boilers industrial best prices SZL 6-1.25-AII horizontal steam boiler.

steam electric boiler with best price made in China 2015 factory price best selling electric heating steam boiler ,electric steam boiler.

Shop our selection of Boilers in the Heating, Venting & Cooling Department at The Home Depot. Set custom price range: $ to $ Go. $50 &8211; $100 (1) · $1000 &8211; $2000 (5) . MegaSteam MST396 Oil Cast Iron Steam Boiler with 95,000 BTU.

Weil Mclain Boilers are one of our specialties on our website. We also sell boilers. These products are all for sale at low prices. Steam (48)

Find great deals on eBay for Used Steam Boiler in Heating Units. or Best Offer reduced price GENERAL BOILER steam boiler 100 PSI MODEL GE-24.

Cost of a Boiler &8211; Estimates and Prices Paid &8211; CostHelper.com

CostHelper readers report paying $3650-$7800 for a replacement boiler, including a boiler heats and distributes water, sending it through pipes as steam to because some of the best deals available are reduced prices for older folks.

Powerhouse sells used boilers and equipment from trusted manufacturers. Benefit from our vast 1-800-37-STEAM. 24/7 Emergency boiler to &8220;like new&8221; condition. Buy with confidence that you&39;re purchasing the best boiler at the best price!

Check out the cast-iron steam boiler selection at Grainger today and find Price $2,251.00 &8211; $3,749.00 .. Oil Fired Steam Boiler,22-1/8inWx35inH.