cheap small coal boiler Portugal

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



Jan 14, 2015 A Decc spokeswoman said that the study&39;s sample had been small and that biomass boilers offered the cheapest short-term way of meeting

Mixing Solar with Coal to Cut Costs | MIT Technology Review

Sep 4, 2009 A new strategy could reduce coal plant emissions and cut the cost of solar power. M&233;xico · Portugal · Espa&241;a · United States · Uruguay . Instead, it will be used to preheat water that will be fed into the coal plant&39;s boilers, where .. However, a lot of small nuclear plants diver

Nov 17, 1998 These cheap fuels are typically different types of waste woods, bark or other biofuels. Furthermore, only small modifications are required in the boiler, are typically quite small compared to the coal-fired power plants. . Portocell, Rodao Mill, Portugal, 1986, 1, 17 MW, Flue gas recycling, Gas combustion

Jun 25, 2009 But coal is killing us by warming the planet, acidifying our lakes and Efficient, small-scale electrical generation is already possible using The gasifier can be built in any convenient place leaving the coal burning boiler intact for fuel or email newsletter today at no cost and receive the latest news and

Dec 26, 2008 With the cost of heating oil and natural gas prone to spikes, some are of the oldest makers of coal-fired furnaces and boilers in the United States, . Still, even amid the steep decline, small upticks similar to the current one

Luxembourg, Netherlands, New Zealand, Norway, Portugal, Spain, Sweden, Switzerland,. Turkey power generation are available now at commercially acceptable cost. The . Although these are small in number and not recently constructed A list of the coal-fired plants, with boiler and turbine suppliers, some key.

Emissions Reductions through Upgrade of Coal-Fired Power Plants

research and analysis on ways to ensure reliable, affordable and clean energy for its New Zealand. Norway. Poland. Portugal. Slovak Republic. Spain. Sweden . Measures to improve the energy efficiency of coal power plants . .. efficiency has been to improve combustion performance and optimise boiler efficiency; to.

Since the ROC price is not dependent on the technology, the least cost, lowest risk The co-firing of biomass in coal-fired power plants is eligible under the The technical options for co-firing biomass in large pulverised coal-fired boilers present, but only in small quantities for test and small-scale commercial purposes.

Sep 27, 2015 The Small Coal Boiler is a steam generator that is powered by coal. This will usually be the way you will obtain your first steam for powering

Jan 14, 2015 A Decc spokeswoman said that the study&39;s sample had been small and that biomass boilers offered the cheapest short-term way of meeting

Sep 4, 2009 A new strategy could reduce coal plant emissions and cut the cost of solar power. M&233;xico · Portugal · Espa&241;a · United States · Uruguay . Instead, it will be used to preheat water that will be fed into the coal plant&39;s boilers, where .. However, a lot of small nuclear plants diver

Biomass CFB gasifier connected to a 350 MWth steam boiler fired

Nov 17, 1998 These cheap fuels are typically different types of waste woods, bark or other biofuels. Furthermore, only small modifications are required in the boiler, are typically quite small compared to the coal-fired power plants. . Portocell, Rodao Mill, Portugal, 1986, 1, 17 MW, Flue gas recycling, Gas combustion

Jun 25, 2009 But coal is killing us by warming the planet, acidifying our lakes and Efficient, small-scale electrical generation is already possible using The gasifier can be built in any convenient place leaving the coal burning boiler intact for fuel or email newsletter today at no cost and receive the latest news and

Dec 26, 2008 With the cost of heating oil and natural gas prone to spikes, some are of the oldest makers of coal-fired furnaces and boilers in the United States, . Still, even amid the steep decline, small upticks similar to the current one

Luxembourg, Netherlands, New Zealand, Norway, Portugal, Spain, Sweden, Switzerland,. Turkey power generation are available now at commercially acceptable cost. The . Although these are small in number and not recently constructed A list of the coal-fired plants, with boiler and turbine suppliers, some key.

research and analysis on ways to ensure reliable, affordable and clean energy for its New Zealand. Norway. Poland. Portugal. Slovak Republic. Spain. Sweden . Measures to improve the energy efficiency of coal power plants . .. efficiency has been to improve combustion performance and optimise boiler efficiency; to.

A review of the recent experience in Britain with the &8211; IEA Bioenergy

Since the ROC price is not dependent on the technology, the least cost, lowest risk The co-firing of biomass in coal-fired power plants is eligible under the The technical options for co-firing biomass in large pulverised coal-fired boilers present, but only in small quantities for test and small-scale commercial purposes.

Sep 27, 2015 The Small Coal Boiler is a steam generator that is powered by coal. This will usually be the way you will obtain your first steam for powering