coal based captive power plants boiler details Kota Sorong

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



A thermal power station is a power plant in which the Typical coal thermal power to built near any water body like Kota Super Thermal Power Station is

DCM Shriram Consolidated &8211; SourceWatch

DCM Shriram Consolidated fired boiler at the Bharuch DCM power station Gujarat with full coal based captive power. With increasing coal costs eroding

Advantages of coal based thermal Power Plant. Kota Super Thermal Power Plant: RVUNL: Kota: about which type of burner used in ukai thermal power plant in boiler

4 Mar 2012 In a coal based thermal power plant, Power Plant Service, Boiler Coal lignite handling systems for Captive and Thermal Power Plants.

(with captive power plants The total emission rates are calculated based on the boiler size, coal has one coal based power plant in Trombay

The Cement Division has two high-ash coal-based captive power plants at 2010 : power plant, chemist, boiler, dcs mixing plant at Kota

HIGH VOLUME FLY ASH CONCRETE TECHNOLOGY

radius of fifty to one hundred kilometres from a coal or lignite based thermal power plant shall use fly ash Coal 1,000 Kota Fly ash details Name of plant

CAPTIVE POWER PLANT 500 MW coal based super thermal power plants block diagram of a robot in nuclear power plant. Get details of block diagram of a

Here is some list of currently operating Coal based Thermal power plants in THERMAL POWER PLANT kota Super Thermal Power Station from captive coal

Limestone mines and Captive power plant. of the cement plant and washery and the coal based suitability of the rejects in the existing coal fired boiler

DCM Shriram Consolidated fired boiler at the Bharuch DCM power station Gujarat with full coal based captive power. With increasing coal costs eroding

Thermal Power Plant Working | Indian Power Sector.com

Advantages of coal based thermal Power Plant. Kota Super Thermal Power Plant: RVUNL: Kota: about which type of burner used in ukai thermal power plant in boiler

4 Mar 2012 In a coal based thermal power plant, Power Plant Service, Boiler Coal lignite handling systems for Captive and Thermal Power Plants.

(with captive power plants The total emission rates are calculated based on the boiler size, coal has one coal based power plant in Trombay

The Cement Division has two high-ash coal-based captive power plants at 2010 : power plant, chemist, boiler, dcs mixing plant at Kota

radius of fifty to one hundred kilometres from a coal or lignite based thermal power plant shall use fly ash Coal 1,000 Kota Fly ash details Name of plant

block diagram of super thermal power plant &8211; BINQ Mining

CAPTIVE POWER PLANT 500 MW coal based super thermal power plants block diagram of a robot in nuclear power plant. Get details of block diagram of a

Here is some list of currently operating Coal based Thermal power plants in THERMAL POWER PLANT kota Super Thermal Power Station from captive coal

Limestone mines and Captive power plant. of the cement plant and washery and the coal based suitability of the rejects in the existing coal fired boiler

development of an emission inventory for coal-based power plants (including private and captive power plants) Details of coal-based thermal power plants