steam coal boile

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



In electricity generation, thermal coal is ground to a powder and fired into a boiler to produce heat, which in turn converts water into steam. The steam powers a

coal electricity, coal power plants &8211; World Coal Association

Steam coal, also known as thermal coal, is used in power stations to gases and heat energy produced converts water &8211; in tubes lining the boiler &8211; into steam.

The High Pressure Coal Boiler is a steam generator powered by coal/charcoal. As you build more and more machines, the Small Coal Boiler will prove to be too

coal > Clean burning Automatic boilers Coal furnaces are designed for ease of installation and easy access for servicing Steam or hot water boiler

These impurities producer certain waste during combustion of coal and remain in the form of ash and stored in the ash pit of steam boiler furnace , after

Steam Boiler Furnace Grate Firebox Combustion Chamber of Furnace There are mainly two methods of firing steam boiler with coal as fuel. One is solid fuel

Coal Fired Thermal Power Plant &8211; Bright Hub Engineering

Sep 8, 2011 The heat from combustion of the coal boils water in the boiler to produce steam. In modern power plant, boilers produce steam at a high

For each kind of coal there is some method of firing which will give the best . in his &8220;Steam Boiler Economy&8221;, described the action of bituminous coal after it is

Hurst Boiler has been manufacturing, designing, engineering and servicing gas, oil, coal, solid waste, wood, biomass and hybrid fuel fired steam and hot water

Jun 24, 2015 The Small Coal Boiler is a machine added by the GregTech mod, which can be used to create Steam by filling it with water and burning Coal or

Results 1 &8211; 19 of 19 Welcome to the most trusted and comprehensive Boilers: Steam, Coal Fired directory on the Internet. A broad range of Boilers: Steam, Coal

Boilers for steam power plants &8211; Alstom

Product Catalogue: Boilers for steam power plants. Country: Germany Pulverised coal tower type boiler: market leading boiler technology for all types of coal.

In a coal-fired steam station&8212;much like a nuclear station&8212;water is turned into steam, pumped through pipes inside the boiler, is turned into steam by the heat.

In electricity generation, thermal coal is ground to a powder and fired into a boiler to produce heat, which in turn converts water into steam. The steam powers a

Steam coal, also known as thermal coal, is used in power stations to gases and heat energy produced converts water &8211; in tubes lining the boiler &8211; into steam.

The High Pressure Coal Boiler is a steam generator powered by coal/charcoal. As you build more and more machines, the Small Coal Boiler will prove to be too